| Citation: |
YAN Min，HUO Shihao，LIN Haifei，et al. Study on influence of different factors on the peak concentration distribution of desorption gas under the action of gas sustained-release agent[J]. Coal Science and Technology，2023，51（12）：282−297. DOI: 10.13199/j.cnki.cst.2022-2209
|
In order to prevent coal mine gas accidents and realize efficient and accurate gas extraction, spraying gas sustained-release agent in local high concentration gas area has become one of the important means to prevent and control gas overlimit. The self-developed multi-factor influencing coal gas desorption and spraying experiment platform, built based on the similarity ratio model of coal mine driving working face, was used to study the law of different factors affecting the peak concentration distribution of desorbed gas under spraying gas sustained-release agent. The effects of APG solution mass fraction, atomizing pressure, coal sample particle size, equilibrium pressure, ambient temperature, wind speed and other factors on the peak concentration distribution of desorbed gas were analyzed. The Pearson correlation coefficient method was used to obtain the correlation between the factors and the peak gas concentration in different areas after spraying gas sustained-release agent. The results shown that, the peak gas concentration declined rapidly with increasing mass fraction for APG solution mass fraction less than 0.10%, and the decline rate decreased when it exceeded 0.10%. Under the effect of sustained-release agent, the peak gas concentration shown negative linear and negative exponential relationship with atomization pressure and coal sample particle size, respectively. The peak gas concentration decreased with the increase of atomization pressure and coal sample particle size, and the maximum gas reduction rate was observed when the coal sample particle size was 5-10 mm. The peak gas concentration shown linear and exponential relationship with equilibrium pressure and ambient temperature, respectively. The peak gas concentration increased with the increase of equilibrium pressure and ambient temperature, and the growth rate of peak gas concentration was the highest when the ambient temperature was 35 °C. The peak gas concentration at the center and corners of the working face model decreased with increasing wind speed, and the reduction rate of peak gas concentration decreased when the wind speed exceeded 12.7×10−3 m3/s. The peak gas concentration was reduced by 4.3%-8.0% with multiple factors compared to a single factor. Using the correlation coefficient method, the maximum factors affecting the peak gas concentration at the upper and lower corners of the inlet, upper and lower corners of the outlet, and the center of the model were obtained as atomization pressure, atomization pressure, equilibrium pressure, ambient temperature and equilibrium pressure, respectively.
| [1] |
周守为,朱军龙. 助力“碳达峰、碳中和”战略的路径探索[J]. 天然气工业,2021,41(12):1−8.
ZHOU Shouwei,ZHU Junlong. Help to explore the path of “carbon peak and carbon neutrality” strategy[J]. Natural Gas Industry,2021,41(12):1−8.
|
| [2] |
LI X,ZHAO D,ZHANG C,QIN Y. Gas desorption characteristics and related mechanism analysis under the action of superheated steam and pressurized water based on an experimental study[J]. Journal of Natural Gas Science and Engineering,2021,96:104268. doi: 10.1016/j.jngse.2021.104268
|
| [3] |
魏建平,位 乐,王登科. 含水率对含瓦斯煤的渗流特性影响试验研究[J]. 煤炭学报,2014,39(1):97−103.
WEI Jianping,WEI Le,WANG Dengke. Experimental study on the effect of moisture content on seepage characteristics of gas-bearing coal[J]. Journal of China Coal Society,2014,39(1):97−103.
|
| [4] |
林海飞,刘宝莉,严 敏. 表面活性剂对煤体瓦斯解吸性能影响的试验研究[J]. 煤炭工程,2017,49(12):136−140.
LIN Haifei,LIU Baoli,YAN Min. Experimental study on the effect of surfactants on coal gas desorption performance[J]. Coal Engineering,2017,49(12):136−140.
|
| [5] |
LI P,MA D M,ZHAN J C,et al. Wettability modification and its influence on methane adsorption/desorption:a case study in the Ordos Basin,China[J]. Energy Science & Engineering,2020,8(3):804−816. doi: 10.1002/ese3.552
|
| [6] |
严 敏,岳 敏,林海飞,等. 中低阶煤官能团对煤润湿性影响试验研究[J]. 煤炭科学技术,2023,51(5):103−113. doi: 10.13199/j.cnki.cst.2021-1097
YAN Min,YUE Min,LIN Haifei,et al. Experimental study on the influence of middle and low rank coal functional groups on coal wettability[J]. Coal Science and Technology,2023,51(5):103−113. doi: 10.13199/j.cnki.cst.2021-1097
|
| [7] |
MENG J Q,LI S C,NIU J X,et al. Effects of moisture on methane desorption characteristics of the Zhaozhuang coal:experiment and molecular simulation[J]. Environmental Earth Sciences,2020,79:1−16. doi: 10.1007/s12665-019-8788-9
|
| [8] |
聂百胜,杨 涛,李祥春,等. 煤粒瓦斯解吸扩散规律试验[J]. 中国矿业大学学报,2013,42(6):975−981.
NIE Baisheng,YANG Tao,LI Xiangchun,et al. Experiment on desorption and diffusion law of coal particle gas[J]. Journal of China University of Mining and Technology,2013,42(6):975−981.
|
| [9] |
何满潮,王春光,李德建,等. 单轴应力–温度作用下煤中吸附瓦斯解吸特征[J]. 岩石力学与工程学报,2010,29(5):865−872.
HE Manchao,WANG Chunguang,LI Dejian,et al. Desorption characteristics of adsorbed gas in coal under uniaxial stress-temperature effect[J]. Chinese Journal of Rock Mechanics and Engineering,2010,29(5):865−872.
|
| [10] |
王兆丰,岳高伟,康 博,等. 低温环境对煤的瓦斯解吸抑制效应试验[J]. 重庆大学学报,2014,37(9):106−112,143.
WANG Zhaofeng,YUE Gaowei,KANG Bo,et al. Experiment on inhibitory effect of low temperature environment on gas desorption of coal[J]. Journal of Chongqing University,2014,37(9):106−112,143.
|
| [11] |
刘彦伟,刘明举. 粒度对软硬煤粒瓦斯解吸扩散差异性的影响[J]. 煤炭学报,2015,40(3):579−587.
LIU Yanwei,LIU Mingju. Effect of particle size on the difference of gas desorption and diffusion of soft and hard coal particles[J]. Journal of China Coal Society,2015,40(3):579−587.
|
| [12] |
GAO T,ZHAO D,WANG C,et al. Energy variation in coal samples with different particle sizes in the process of adsorption and desorption[J]. Journal of Petroleum Science and Engineering,2020,188:106932. doi: 10.1016/j.petrol.2020.106932
|
| [13] |
李祥春,李忠备,张 良,等. 不同煤阶煤样孔隙结构表征及其对瓦斯解吸扩散的影响[J]. 煤炭学报,2019,44(S1):142−156.
LI Xiangchun,LI Zhongbei,ZHANG Liang,et al. Characterization of pore structure of coal samples with different ranks and their effects on gas desorption and diffusion[J]. Journal of China Coal Society,2019,44(S1):142−156.
|
| [14] |
陈向军,李立杨,杜云飞,等. 粒径和吸附平衡压力对无烟煤残存瓦斯含量的影响[J]. 煤矿安全,2018,49(9):1−5.
CHEN Xiangjun,LI Liyang,DU Yunfei,et al. Effects of particle size and adsorption equilibrium pressure on residual gas content in anthracite coal[J]. Safety in Coal Mines,2018,49(9):1−5.
|
| [15] |
LI X C,LI Z B,REN T,et al. Effects of particle size and adsorption pressure on methane gas desorption and diffusion in coal[J]. Arabian Journal of Geosciences,2019,12(24):794. doi: 10.1007/s12517-019-4995-7
|
| [16] |
李树刚,秦雪燕,白 杨,等. 煤吸附瓦斯影响因素的正交设计试验研究[J]. 矿业安全与环保,2022,49(4):72−79.
LI Shugang,QIN Xueyan,BAI Yang,et al. Orthogonal design experimental study on the influencing factors of gas adsorption by coal[J]. Mining Safety and Environmental Protection,2022,49(4):72−79.
|
| [17] |
WANG F K,LIANG Y P,LI X L,et al. Orthogonal experimental study on multifactor conditions for gas desorption in coal[J]. Advances in Civil Engineering,2019,2019:3028721.
|
| [18] |
魏宗勇,薛梦华,胡宇航,等. 煤的瓦斯放散特性多因素影响试验[J]. 煤矿安全,2019,50(9):9−12.
WEI Zongyong,XUE Menghua,HU Yuhang,et al. Multi-factor influence experiment on gas emission characteristics of coal[J]. Safety in Coal Mines,2019,50(9):9−12.
|
| [19] |
刘 丹. 表面活性剂影响煤体瓦斯解吸效应的试验研究[D]. 西安: 西安科技大学, 2019.
LIU Dan. Experimental study on the effect of surfactant on coal gas desorption [D]. Xi’an: Xi’an University of Science and Technology, 2019.
|
| [20] |
李青松,李国红,王恩元,等. 基于经典扩散模型不同粒径粒煤瓦斯扩散特征试验研究[J]. 中国安全生产科学技术,2018,14(9):44−49.
LI Qingsong,LI Guohong,WANG Enyuan,et al. Experimental study on gas diffusion characteristics of granular coal with different particle sizes based on classical diffusion model[J]. China Safety Production Science and Technology,2018,14(9):44−49.
|
| [21] |
唐明云,张海路,段三壮,等. 基于Langmuir模型温度对煤吸附解吸甲烷影响研究[J]. 煤炭科学技术,2021,49(5):182−189.
TANG Mingyun,ZHANG Hailu,DUAN Sanzhuang,et al. Study on the effect of temperature on coal adsorption and desorption of methane based on Langmuir model[J]. Coal Science and Technology,2021,49(5):182−189.
|
| [22] |
李晓伟,蒋承林,季 明,等. 初始释放瓦斯膨胀能与煤体破碎程度的关系研究[J]. 煤矿安全,2008,39(5):1−3,7.
LI Xiaowei,JIANG Chenglin,JI Ming,et al. Study on the relationship between initial release gas expansion energy and coal crushing degree[J]. Safety in Coal Mines,2008,39(5):1−3,7.
|
| [23] |
李树刚,闫冬洁,严 敏,等. 烷基糖苷活性剂对煤体结构改性及甲烷解吸特性的影响[J]. 煤炭学报,2022,47(1):286−296.
LI Shugang,YAN Dongjie,YAN Min,et al. Effects of alkyl glycoside activators on coal structure modification and methane desorption characteristics[J]. Journal of China Coal Society,2022,47(1):286−296.
|
| [24] |
刘 谦,郭玉森,赖永明,等. 煤的吸附特性与表面能关系的试验研究[J]. 煤矿安全,2015,46(9):20−22,26.
LIU Qian,GUO Yusen,LAI Yongming,et al. Experimental study on the relationship between adsorption characteristics and surface energy of coal[J]. Safety in Coal Mines,2015,46(9):20−22,26.
|
| [25] |
施智雄,潘科玮,平 力,等. 喷嘴雾化参数轨迹图像法测量试验研究[J]. 化工学报,2020,71(8):3527−3534.
SHI Zhixiong,PAN Kewei,PING Li,et al. Experimental study on nozzle atomization parameter trajectory image method[J]. Journal of Chemical Industry,2020,71(8):3527−3534.
|
| [26] |
刘纪坤,任 棒,王翠霞. 中低阶煤孔隙结构特征及其对瓦斯解吸特性影响[J]. 煤炭科学技术,2022,50(12):153−161. doi: 10.13199/j.cnki.cst.2021-0775
LIU Jikun,REN Bang,WANG Cuixia. Pore structure characteristics of middle and low rank coals and their influence on gas desorption characteristics[J]. Coal Science and Technology,2022,50(12):153−161. doi: 10.13199/j.cnki.cst.2021-0775
|
| [27] |
秦 雷,林海飞,兰世瑞,等. 低温液氮作用下煤体瓦斯吸附特性试验研究[J]. 煤炭科学技术,2020,48(10):105−112.
QIN Lei,LIN Haifei,LAN Shirui,et al. Experimental study on coal gas adsorption characteristics under action of low temperature liquid nitrogen[J]. Coal Science and Technology,2020,48(10):105−112.
|
| [28] |
苏现波,林晓英,赵孟军,等. 储层条件下煤吸附甲烷能力预测[J]. 天然气工业,2006,26(8):34−36,160.
SU Xianbo,LIN Xiaoying,ZHAO Mengjun,et al. Prediction of methane adsorption capacity of coal under reservoir conditions[J]. Natural Gas Industry,2006,26(8):34−36,160.
|
| [29] |
严 敏,龙 航,白 杨,等. 温度效应对煤层瓦斯吸附解吸特性影响的试验研究[J]. 矿业安全与环保,2019,46(3):6−10.
YAN Min,LONG Hang,BAI Yang,et al. Experimental study on the effect of temperature on coalbed gas adsorption and desorption characteristics[J]. Mining Safety and Environmental Protection,2019,46(3):6−10.
|
| [30] |
马兴莹,王兆丰,尉 瑞,等. 低温环境瓦斯扩散试验及不同模型契合度分析[J]. 中国安全科学学报,2022,32(3):123−130.
MA Xingying,WANG Zhaofeng,WEI Rui,et al. Low temperature environment gas diffusion test and analysis of fit of different models[J]. Chinese Journal of Safety Science,2022,32(3):123−130.
|
| [31] |
刘光文,杜志锋,周秋娟,等. 综采工作面风速与瓦斯浓度分布规律实测与分析[J]. 煤炭科学技术,2018,46(S1):127−130.
LIU Guangwen,DU Zhifeng,ZHOU Qiujuan,et al. Measurement and analysis of wind speed and gas concentration distribution in fully mechanized mining face[J]. Coal Science and Technology,2018,46(S1):127−130.
|
| [32] |
刘 健,刘银坤. 基于Pearson系数对气象因子与污染物的相关性研究[J]. 华北科技学院学报,2019,16(4):93−97.
LIU Jian,LIU Yinkun. Correlation between meteorological factors and pollutants based on Pearson coefficient[J]. Journal of North China Institute of Science and Technology,2019,16(4):93−97.
|
| 1. |
刘江斌，任建超，刘茂福，赵燚，白荣财，高卫卫，肖琪. 基于智能算法的煤矿瓦斯浓度随钻预测模型对比研究. 工业仪表与自动化装置. 2024(06): 109-113 .
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: