| Citation: |
ZHANG Yun，ZHANG Long，LAI Xingping，et al. Study on stability control of stope structural in short-wall cemented backfill mining for recovery of room-and-pillar residual coal[J]. Coal Science and Technology，2025，53（6）：357−372. DOI: 10.12438/cst.2025-0275
|
The stagnation of residual coal pillars from room-and-pillar mining and the discharge of mine solid waste have severely constrained the green and low-carbon transformation of China’s coal industry. To address these challenges, the Bandingliang Coal Mine in northern Shaanxi as the engineering case study, a novel "time-sequence coordinated pillar replacement" short-wall cemented backfill mining technique was proposed. First, the safe stress for the recovery of residual coal pillars from room-and-pillar mining was calculated based on the limit strength theory. Secondly, numerical simulation was used to study the instability characteristics of the natural collapse method for managing the recovery of residual coal pillars and the impact of roof failure on the stability of the mining area. A mechanical model for the short-wall cemented backfill stope was established, and the critical strength of the backfill material was solved to ensure that the direct roof would not fail. Finally, mechanical tests were performed to analyze the mechanical properties, failure characteristics, and microstructural features of the cemented backfill, and a complete design method for short-wall cemented backfill mining was proposed based on the actual engineering. The results indicated that the safe stress value for the residual coal pillar in Bandingliang Coal Mine was 11.78 MPa, which met the conditions for safe recovery. Based on the stress, plastic zone distribution characteristics, and roof failure analysis during the recovery of residual coal pillars using the natural caving method, It was discovered that the recycling process may trigger a “domino” chain reaction, accompanied by large-scale roof failure. Furthermore, the short-wall cemented backfill mining technique was proposed to replace the residual coal pillars, and the critical backfill strength required to prevent roof collapse was calculated to be 8.97 MPa. Based on this, the optimal mix ratio of coal gangue∶fly ash∶cement∶water in the backfill material was determined as 3∶3∶1∶1. This mix ratio provided superior gangue particle grading, and the hydration products densely filled the gaps between aggregates, effectively reducing porosity and significantly improving mechanical performance, thus meeting the safe recovery requirements for coal pillars in Bandingliang Coal Mine. Feasibility designs for the short-wall cemented backfill mining production system and key parameters in the experimental recovery area were proposed, along with control measures to ensure the effectiveness of the backfill. The research results provided a replicable engineering paradigm for the “resource recovery-ecological protection-solid waste utilization” integrated green and low-carbon transformation and development of the coal industry in China.
| [1] |
王双明,刘浪,赵玉娇,等. “双碳” 目标下赋煤区新能源开发:未来煤矿转型升级新路径[J]. 煤炭科学技术,2023,51(1):59−79.
WANG Shuangming,LIU Lang,ZHAO Yujiao,et al. New energy exploitation in coal-endowed areas under the target of “double carbon”:A new path for transformation and upgrading of coal mines in the future[J]. Coal Science and Technology,2023,51(1):59−79.
|
| [2] |
王国法,刘合,王丹丹,等. 新形势下我国能源高质量发展与能源安全[J]. 中国科学院院刊,2023,38(1):23−37.
WANG Guofa,LIU He,WANG Dandan,et al. High-quality energy development and energy security under the new situation for China[J]. Bulletin of Chinese Academy of Sciences,2023,38(1):23−37.
|
| [3] |
张吉雄,张强,周楠,等. 煤基固废充填开采技术研究进展与展望[J]. 煤炭学报,2022,47(12):4167−4181.
ZHANG Jixiong,ZHANG Qiang,ZHOU Nan,et al. Research progress and prospect of coal based solid waste backfilling mining technology[J]. Journal of China Coal Society,2022,47(12):4167−4181.
|
| [4] |
钱鸣高. 煤炭的科学开采[J]. 煤炭学报,2010,35(4):529−534.
QIAN Minggao. On sustainable coal mining in China[J]. Journal of China Coal Society,2010,35(4):529−534.
|
| [5] |
杨科,何淑欣,何祥,等. 煤电化基地大宗固废“三化” 协同利用基础与技术[J]. 煤炭科学技术,2024,52(4):69−82. doi: 10.12438/cst.2024-0129
YANG Ke,HE Shuxin,HE Xiang,et al. Foundation and technology of coordinated utilization of bulk solid waste ‘Three modernizations’ in coal power base[J]. Coal Science and Technology,2024,52(4):69−82. doi: 10.12438/cst.2024-0129
|
| [6] |
冯国瑞,张玉江,戚庭野,等. 中国遗煤开采现状及研究进展[J]. 煤炭学报,2020,45(1):151−159.
FENG Guorui,ZHANG Yujiang,QI Tingye,et al. Status and research progress for residual coal mining in China[J]. Journal of China Coal Society,2020,45(1):151−159.
|
| [7] |
胡振琪,理源源,李根生,等. 碳中和目标下矿区土地复垦与生态修复的机遇与挑战[J]. 煤炭科学技术,2023,51(1):474−483.
HU Zhenqi,LI Yuanyuan,LI Gensheng,et al. Opportunities and Challenges of Land Reclamation and Ecological Restoration in Mining Areas under the Goal of Carbon Neutrality[J]. Coal Science and Technology,2023,51(1):474−483.
|
| [8] |
郭广礼,李怀展,查剑锋,等. 平原煤粮主产复合区煤矿开采和耕地保护协同发展研究现状及对策[J]. 煤炭科学技术,2023,51(1):416−426.
GUO Guangli,LI Huaizhan,ZHA Jianfeng,et al. Research status and countermeasures of coordinated development of coal mining and cultivated land protection in the plain coal-cropland overlapped areas[J]. Coal Science and Technology,2023,51(1):416−426.
|
| [9] |
张云,刘永孜,曹胜根,等. 短壁块段式充填采煤矸石充填材料重金属离子“下行” 迁移规律及控制技术[J]. 采矿与安全工程学报,2023,40(2):284−294.
ZHANG Yun,LIU Yongzi,CAO Shenggen,et al. Study on the migration law and control of heavy metal ions “downward” in gangue backfill materials in short-wall block backfill mining[J]. Journal of Mining & Safety Engineering,2023,40(2):284−294.
|
| [10] |
MIAO Z K,WU J J,NIU Y J,et al. Development of a novel type hierarchical porous composite from coal gasification fine slag for CO2 capture[J]. Chemical Engineering Journal,2022,435:134909. doi: 10.1016/j.cej.2022.134909
|
| [11] |
张云,刘永孜,来兴平,等. 基于导水裂隙扩展−重金属离子迁移的短壁块段式充填保水采煤机理研究[J]. 煤炭科学技术,2023,51(2):155−172.
ZHANG Yun,LIU Yongzi,LAI Xingping,et al. Mechanism of short-wall block backfill water-preserved mining based on water-conducting fractures development-heavy metal ions migration[J]. Coal Science and Technology,2023,51(2):155−172.
|
| [12] |
谢和平,张吉雄,高峰,等. 煤矿负碳高效充填开采理论与技术构想[J]. 煤炭学报,2024,49(1):36−46.
XIE Heping,ZHANG Jixiong,GAO Feng,et al. Theory and technical conception of carbon-negative and high-efficient backfill mining in coal mines[J]. Journal of China Coal Society,2024,49(1):36−46.
|
| [13] |
张彦禄,王步康,张小峰,等. 我国连续采煤机短壁机械化开采技术发展40 a与展望[J]. 煤炭学报,2021,46(1):86−99.
ZHANG Yanlu,WANG Bukang,ZHANG Xiaofeng,et al. Forty years' development and future prospect on mechanized short-wall mining technology with continuous miner in China[J]. Journal of China Coal Society,2021,46(1):86−99.
|
| [14] |
吴群英,胡俭,刘凯,等. 浅埋多煤层群协调绿色开采关键技术研发与实践[J]. 煤炭科学技术,2024,52(9):19−30. doi: 10.12438/cst.2024-1095
WU Qunying,HU Jian,LIU Kai,et al. Research and practice on key technologies for coordinated green mining of shallowly buried multi-coal seam groups[J]. Coal Science and Technology,2024,52(9):19−30. doi: 10.12438/cst.2024-1095
|
| [15] |
冯国瑞,白锦文,史旭东,等. 遗留煤柱群链式失稳的关键柱理论及其应用展望[J]. 煤炭学报,2021,46(1):164−179.
FENG Guorui,BAI Jinwen,SHI Xudong,et al. Key pillar theory in the chain failure of residual coal pillars and its application prospect[J]. Journal of China Coal Society,2021,46(1):164−179.
|
| [16] |
冯国瑞,马俊彪,白锦文,等. 关键柱柱旁双侧充填遗留煤柱链式失稳防控效果研究[J]. 采矿与安全工程学报,2023,40(5):945−956.
FENG Guorui,MA Junbiao,BAI Jinwen,et al. Study of the prevention and control effect of residual coal pillars' chain failure after key pillar-double side backfilling[J]. Journal of Mining & Safety Engineering,2023,40(5):945−956.
|
| [17] |
李文,王东昊,李宏杰,等. 煤矿采空区失稳灾害链式效应与链式类型研究[J]. 煤炭科学技术,2020,48(7):288−295.
LI Wen,WANG Donghao,LI Hongjie,et al. Study on chain effect and type of coal mine goafs instability disaster[J]. Coal Science and Technology,2020,48(7):288−295.
|
| [18] |
曹胜根,曹洋,姜海军. 块段式开采区段煤柱突变失稳机理研究[J]. 采矿与安全工程学报,2014,31(6):907−913.
CAO Shenggen,CAO Yang,JIANG Haijun. Research on catastrophe instability mechanism of section coal pillars in block mining[J]. Journal of Mining & Safety Engineering,2014,31(6):907−913.
|
| [19] |
WANG X R,YANG T H,GUAN K,et al. Stability evaluation of multi-pillar and roof system based on instability theory[J]. Rock Mechanics and Rock Engineering,2022,55(3):1461−1480. doi: 10.1007/s00603-021-02712-8
|
| [20] |
张云,曹胜根,来兴平,等. 短壁块段式采煤覆岩导水裂隙发育力学特性分析[J]. 煤炭学报,2020,45(S2):551−560.
ZHANG Yun,CAO Shenggen,LAI Xingping,et al. Mechanical characteristics analysis of water-conducting fracture development in overlying strata of short-wall block mining[J]. Journal of China Coal Society,2020,45(S2):551−560.
|
| [21] |
张云,曹胜根,来兴平,等. 短壁块段式充填采煤覆岩导水裂隙发育机理及控制研究[J]. 采矿与安全工程学报,2019,36(6):1086−1092.
ZHANG Yun,CAO Shenggen,LAI Xingping,et al. Study on the development mechanism and control of water-conducting fractures in short-wall block backfill mining[J]. Journal of Mining & Safety Engineering,2019,36(6):1086−1092.
|
| [22] |
安百富,张吉雄,李猛,等. 充填回收房式煤柱采场煤柱稳定性分析[J]. 采矿与安全工程学报,2016,33(2):238−243.
AN Baifu,ZHANG Jixiong,LI Meng,et al. Stability of pillars in backfilling mining working face to recover room mining standing pillars[J]. Journal of Mining & Safety Engineering,2016,33(2):238−243.
|
| [23] |
朱德福,屠世浩,王方田,等. 浅埋房式采空区煤柱群稳定性评价[J]. 煤炭学报,2018,43(2):390−397.
ZHU Defu,TU Shihao,WANG Fangtian,et al. Stability evaluation on pillar system of room and pillar mining in goaf at shallow depth seam[J]. Journal of China Coal Society,2018,43(2):390−397.
|
| [24] |
GHASEMI E,SHAHRIAR K. A new coal pillars design method in order to enhance safety of the retreat mining in room and pillar mines[J]. Safety Science,2012,50(3):579−585. doi: 10.1016/j.ssci.2011.11.005
|
| [25] |
DONOVAN J G,KARFAKIS M G. Design of backfilled thin-seam coal pillars using earth pressure theory[J]. Geotechnical & Geological Engineering,2004,22(4):627−642.
|
| [26] |
张吉雄,缪协兴,郭广礼. 矸石(固体废物)直接充填采煤技术发展现状[J]. 采矿与安全工程学报,2009,26(4):395−401. doi: 10.3969/j.issn.1673-3363.2009.04.001
ZHANG Jixiong,MIAO Xiexing,GUO Guangli. Development status of backfilling technology using raw waste in coal mining[J]. Journal of Mining & Safety Engineering,2009,26(4):395−401. doi: 10.3969/j.issn.1673-3363.2009.04.001
|
| [27] |
张强,杨康,张吉雄,等. 固体充填开采直接顶位态控制机制及工程案例[J]. 中国矿业大学学报,2022,51(1):35−45. doi: 10.3969/j.issn.1000-1964.2022.1.zgkydxxb202201004
ZHANG Qiang,YANG Kang,ZHANG Jixiong,et al. Immediate roof control mechanism in backfill mining method and its engineering case[J]. Journal of China University of Mining & Technology,2022,51(1):35−45. doi: 10.3969/j.issn.1000-1964.2022.1.zgkydxxb202201004
|
| [28] |
郭宇鸣,刘恒凤,殷伟,等. 充填与垮落协同开采覆岩层间滑移破坏规律研究[J]. 煤炭科学技术,2022,50(5):92−103.
GUO Yuming,LIU Hengfeng,YIN Wei,et al. Study on slip damage law between overburden layers of backfilling collaborate with caving fully-mechanized mining[J]. Coal Science and Technology,2022,50(5):92−103.
|
| [29] |
WANG S S,YANG R S,LI Y L,et al. Single-factor analysis and interaction terms on the mechanical and microscopic properties of cemented aeolian sand backfill[J]. International Journal of Minerals,Metallurgy and Materials,2023,30(8):1584−1595.
|
| [30] |
邵小平,陶叶青,刘二帅,等. 陕北浅埋煤层似膏体充填条带开采参数研究及应用[J]. 煤炭科学技术,2021,49(7):63−70.
SHAO Xiaoping,TAO Yeqing,LIU Ershuai,et al. Study and application of paste-like filling mining parameters of shallow buried coal seam in Northern Shaanxi[J]. Coal Science and Technology,2021,49(7):63−70.
|
| [31] |
ZHU X J,GUO G L,LIU H,et al. Experimental research on strata movement characteristics of backfill–strip mining using similar material modeling[J]. Bulletin of Engineering Geology and the Environment,2019,78(4):2151−2167. doi: 10.1007/s10064-018-1301-y
|
| [32] |
LU Z G,JU W J,GAO F Q,et al. Numerical analysis on the factors affecting post-peak characteristics of coal under uniaxial compression[J]. International Journal of Coal Science & Technology,2024,11(1):2.
|
| [33] |
李永亮,路彬,杨仁树,等. 煤矿连采连充式胶结充填采煤技术与典型工程案例[J]. 煤炭学报,2022,47(3):1055−1071.
LI Yongliang,LU Bin,YANG Renshu,et al. Cemented backfilling mining technology with continuous mining and continuous backfilling method for underground coal mine and typical engineering cases[J]. Journal of China Coal Society,2022,47(3):1055−1071.
|
| [34] |
刘浪,罗屹骁,朱梦博,等. 建筑物下特厚煤层镁渣基全固废连采连充开采技术与实践[J]. 煤炭科学技术,2024,52(4):83−92.
LIU Lang,LUO Yixiao,ZHU Mengbo,et al. Technology and Practice of Continuous Mining and Filling with Magnesium Slag-Based Solid Waste in Extra-Thick Coal Seams under Buildings[J]. Coal Science and Technology,2024,52(4):83−92.
|
| [35] |
YANG Y B,LAI X P,ZHANG Y,et al. Strength deterioration and energy dissipation characteristics of cemented backfill with different gangue particle size distributions[J]. Journal of Materials Research and Technology,2023,25:5122−5135. doi: 10.1016/j.jmrt.2023.06.279
|
| [36] |
李晓磊,杜献杰,冯国瑞,等. 水泥–粉煤灰基矸石胶结充填体破坏特征及强度形成机制[J]. 煤炭科学技术,2024,52(5):36−45 doi: 10.12438/cst.20230794
LI Xiaolei,DU Xianjie,FENG Guorui,et al. Failure characteristics and strength formation mechanism of cement-fly ash based cemented gangue backfill[J]. Coal Science and Technology,2024,52(5):36−45. doi: 10.12438/cst.20230794
|
| [37] |
JIN J X,QIN Z F,LÜ X L,et al. Rheology control of self-consolidating cement-tailings grout for the feasible use in coal gangue-filled backfill[J]. Construction and Building Materials,2022,316:125836. doi: 10.1016/j.conbuildmat.2021.125836
|
| [38] |
崔希民,逯颖,张兵. 基于载荷转移距离和有效宽度的煤柱稳定性评价方法[J]. 煤炭学报,2017,42(11):2792−2798.
CUI Ximin,LU Ying,ZHANG Bing. Pillar stability evaluation based on load transfer distance and pillar effective width[J]. Journal of China Coal Society,2017,42(11):2792−2798.
|
| [39] |
ZHANG J X,HUANG P,ZHANG Q,et al. Stability and control of room mining coal pillars:Taking room mining coal pillars of solid backfill recovery as an example[J]. Journal of Central South University,2017,24(5):1121−1132. doi: 10.1007/s11771-017-3515-8
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: