| Citation: |
FU Zizhao，BAI Jianbiao，YAN Shuai，et al. Stress superposition characteristics and roof structure control of recovery room in close distance coal seam[J]. Coal Science and Technology，2025，53（6）：383−395. DOI: 10.12438/cst.2024-0420
|
The stress disturbance and complex roof situation of the pre excavation recovery room of the close range coal seam group result in severe damage to the surrounding rock of the tunnel during the construction of the recovery room, making it difficult to control the surrounding rock. Taking the 1205 working face recovery room of a certain mine as the background, a mechanical model of the roof of the close range coal seam group recovery room is constructed, the depth of the upper coal seam working face floor failure is estimated, the evolution law of the roof rock fractures of the lower coal seam recovery room is simulated and inverted, the instability mechanism of this type of tunnel is revealed, and a comprehensive stability control technology for surrounding rock is proposed and verified on site engineering. The results show that: By establishing a mechanical model of the roof of the recovery room during the final mining period, it is determined that under the geological conditions of the mine, the support resistance P1≥3.05 MPa in the recovery room can ensure the stability of the surrounding rock of the recovery room after the working face and recovery room are connected; Using empirical formulas optimized by multiple linear and nonlinear regression analysis, it is estimated that the depth of failure of the upper coal seam working face floor is greater than 8.41 m and less than the interlayer spacing of 13.3 m; Using the UDEC numerical calculation model, the evolution law of cracks on the roof of the recovery room was inverted, and reinforcement measures were taken 10 m in advance for the roof of the recovery room under the goaf, and 15 m in advance for the roof of the recovery room under the coal pillar; Propose a comprehensive stability control technology for the combined active and passive support of anchor cables and individual pillars in the recovery room, as well as the advanced pre cracking of the surrounding rock in the inner roof of the coal pillar lower channel, and apply it to different stress affected areas of the recovery room. The monitoring results of mine pressure indicate that during the construction of the recovery room of the working face, the deformation of the surrounding rock is small, the force changes of the anchor rods and cables are small, and the control effect of the surrounding rock is good, ensuring the safe and efficient retreat of the 1205 working face.
| [1] |
刘畅,杨增强,弓培林,等. 工作面过空巷基本顶超前破断压架机理及控制技术研究[J]. 煤炭学报,2017,42(8):1932−1940.
LIU Chang,YANG Zengqiang,GONG Peilin,et al. Mechanism and control technology of supports crushing induced by main roof’s breaking ahead of workface when crossing abandoned roadway[J]. Journal of China Coal Society,2017,42(8):1932−1940.
|
| [2] |
张永强,王襄禹,李冠军,等. 回撤通道顶板结构失稳机理及压裂控制研究[J]. 采矿与岩层控制工程学报,2022,4(6):27−36.
ZHANG Yongqiang,WANG Xiangyu,LI Guanjun,et al. Research on the instability mechanism of the roof structure and hydraulic fracturing control technology in longwall recovery room[J]. Journal of Mining and Strata Control Engineering,2022,4(6):27−36.
|
| [3] |
侯朝炯,勾攀峰. 巷道锚杆支护围岩强度强化机理研究[J]. 岩石力学与工程学报,2000,19(3):342−345. doi: 10.3321/j.issn:1000-6915.2000.03.019
HOU Chaojiong,GOU Panfeng. Mechanism study on strength enhancement for the rocks surrounding roadway supported by bolt[J]. Chinese Journal of Rock Mechanics and Engineering,2000,19(3):342−345. doi: 10.3321/j.issn:1000-6915.2000.03.019
|
| [4] |
董方庭,宋宏伟,郭志宏,等. 巷道围岩松动圈支护理论[J]. 煤炭学报,1994,19(1):21−32. doi: 10.3321/j.issn:0253-9993.1994.01.005
DONG Fangting,SONG Hongwei,GUO Zhihong,et al. Roadway support theory based on broken rock zone[J]. Journal of China Coal Society,1994,19(1):21−32. doi: 10.3321/j.issn:0253-9993.1994.01.005
|
| [5] |
方新秋,郭敏江,吕志强. 近距离煤层群回采巷道失稳机制及其防治[J]. 岩石力学与工程学报,2009,28(10):2059−2067. doi: 10.3321/j.issn:1000-6915.2009.10.013
FANG Xinqiu,GUO Minjiang,LU Zhiqiang. Instability mechanism and prevention of roadway under close-distance seam group mining[J]. Chinese Journal of Rock Mechanics and Engineering,2009,28(10):2059−2067. doi: 10.3321/j.issn:1000-6915.2009.10.013
|
| [6] |
马全礼,李洪,白景志. 极近距离下位煤层工作面巷道布置及其支护方式[J]. 煤炭科学技术,2006,34(9):37−39. doi: 10.3969/j.issn.0253-2336.2006.09.013
MA Quanli,LI Hong,BAI Jingzhi. Close range sub-coal seam roadway arrangement and its support ways[J]. Coal Science and Technology,2006,34(9):37−39. doi: 10.3969/j.issn.0253-2336.2006.09.013
|
| [7] |
张百胜,杨双锁,康立勋,等. 极近距离煤层回采巷道合理位置确定方法探讨[J]. 岩石力学与工程学报,2008,27(1):97−101. doi: 10.3321/j.issn:1000-6915.2008.01.015
ZHANG Baisheng,YANG Shuangsuo,KANG Lixun,et al. Discussion on the determination method of reasonable position of mining roadway in extremely close distance coal seam[J]. Chinese Journal of Rock Mechanics and Engineering,2008,27(1):97−101. doi: 10.3321/j.issn:1000-6915.2008.01.015
|
| [8] |
谷拴成,王博楠,黄荣宾,等. 综采面末采段回撤通道煤柱荷载与宽度确定方法[J]. 中国矿业大学学报,2015,44(6):990−995.
GU Shuancheng,WANG Bonan,HUANG Rongbin,et al. Method for determining the load on and width of coal pillar at the recovery room end of fully-mechanized longwall mining[J]. Journal of China University of Mining & Technology,2015,44(6):990−995.
|
| [9] |
王博楠,谷拴成,李军. 基于能量计算的预掘回撤通道顶板下沉量分析[J]. 矿业科学学报,2023,8(5):623−632.
WANG Bonan,GU Shuancheng,LI Jun. Analysis on roof sag of pre-driven recovery room based on energy calculation[J]. Journal of Mining Science and Technology,2023,8(5):623−632.
|
| [10] |
王国举,赵伏军,唐辉雄,等. 综采工作面回撤通道顶板结构及支护技术[J]. 矿业工程研究,2013,28(3):15−19. doi: 10.3969/j.issn.1674-5876.2013.03.004
WANG Guoju,ZHAO Fujun,TANG Huixiong,et al. Roof structure and support technology of fully-mechanized coal face quick-return channel[J]. Mineral Engineering Research,2013,28(3):15−19. doi: 10.3969/j.issn.1674-5876.2013.03.004
|
| [11] |
马震,杨月飞. 综采工作面液压支架作为掩护支架快速回撤技术研究[J]. 煤炭工程,2013,45(4):38−40.
MA Zhen,YANG Yuefei. Study on rapid equipment withdrawing technology with hydraulic powered support of fully mechanized coal mining face as shield support[J]. Coal Engineering,2013,45(4):38−40.
|
| [12] |
杨仁树,李永亮,朱晔,等. 特殊条件下大采高工作面回撤通道稳定性控制研究[J]. 煤炭科学技术,2017,45(1):10−15.
YANG Renshu,LI Yongliang,ZHU Ye,et al. Study on stability control of equipment removal channel for high cutting mining face under special condition[J]. Coal Science and Technology,2017,45(1):10−15.
|
| [13] |
闫帅,张栋,柏建彪,等. 回撤通道围岩稳定与主被动联控技术研究[J]. 采矿与安全工程学报,2023,40(4):774−785.
YAN Shuai,ZHANG Dong,BAI Jianbiao,et al. Stability mechanism and active-passive joint control of surrounding rock in longwall recovery room[J]. Journal of Mining & Safety Engineering,2023,40(4):774−785.
|
| [14] |
柏建彪. 沿空掘巷围岩控制[M]. 徐州:中国矿业大学出版社,2006.
|
| [15] |
钱鸣高,许家林,王家臣,等. 矿山压力与岩层控制[M]. 3版. 徐州:中国矿业大学出版社,2021.
|
| [16] |
华心祝,刘淑,刘增辉,等. 孤岛工作面沿空掘巷矿压特征研究及工程应用[J]. 岩石力学与工程学报,2011,30(8):1646−1651.
HUA Xinzhu,LIU Shu,LIU Zenghui,et al. Research on strata pressure characteristic of gob-side entry driving in island mining face and its engineering application[J]. Chinese Journal of Rock Mechanics and Engineering,2011,30(8):1646−1651.
|
| [17] |
李迎富,华心祝,蔡瑞春. 沿空留巷关键块的稳定性力学分析及工程应用[J]. 采矿与安全工程学报,2012,29(3):357−364.
LI Yingfu,HUA Xinzhu,CAI Ruichun. Mechanics analysis on the stability of key block in the gob-side entry retaining and engineering application[J]. Journal of Mining & Safety Engineering,2012,29(3):357−364.
|
| [18] |
温克珩. 深井综放面沿空掘巷窄煤柱破坏规律及其控制机理研究[D]. 西安:西安科技大学,2009.
WEN Keheng. Study on deformation of narrow pillar of roadway driving along next goaf of full caving face and its control in deep coal mine[D]. Xi’an:Xi’an University of Science and Technology,2009.
|
| [19] |
柏建彪,侯朝炯. 空巷顶板稳定性原理及支护技术研究[J]. 煤炭学报,2005,30(1):8−11. doi: 10.3321/j.issn:0253-9993.2005.01.002
BAI Jianbiao,HOU Chaojiong. Research on principle of roof stability of abandoned workings and supporting technology[J]. Journal of China Coal Society,2005,30(1):8−11. doi: 10.3321/j.issn:0253-9993.2005.01.002
|
| [20] |
施龙青,徐东晶,邱梅,等. 采场底板破坏深度计算公式的改进[J]. 煤炭学报,2013,38(S2):299−303.
SHI Longqing,XU Dongjing,QIU Mei,et al. Improvement of formula for calculating failure depth of stope floor[J]. Journal of China Coal Society,2013,38(S2):299−303.
|
| [21] |
王存文,姜福兴,王平,等. 煤柱诱发冲击地压的微震事件分布特征与力学机理[J]. 煤炭学报,2009,34(9):1169−1173. doi: 10.3321/j.issn:0253-9993.2009.09.004
WANG Cunwen,JIANG Fuxing,WANG Ping,et al. Microseismic events distribution characteristics and mechanical mechanisms of rock bursting induced by a coal pillar[J]. Journal of China Coal Society,2009,34(9):1169−1173. doi: 10.3321/j.issn:0253-9993.2009.09.004
|
| 1. |
刘譞, 姬亚东, 朱开鹏, 赵春虎, 李凯, 李超峰, 袁晨瀚, 李盼盼, 闫鹏珍. 煤层顶板涌水量TCN-LSTM-SVM时间序列预测模型构建与应用. 煤田地质与勘探. 2025(06)
| |
| 2. |
郑学召，马佳文，黄渊，李强，任婧，刘钰. 面向矿山救援的UWB雷达人员定位研究现状及展望. 工矿自动化. 2025(04): 9-18 .
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: