| Citation: |
ZHAO Tian，XU Yongliang，WANG Lanyun，et al. Experimental study on purification of low concentration coalbed methane by hydrate method under amino acid system[J]. Coal Science and Technology，2025，53（S1）：139−150. DOI: 10.12438/cst.2023-1982
|
The development and utilization of low-concentration gas resources is of great significance to alleviate the problems of energy shortage and unreasonable consumption structure. Leucine and tryptophan are highly effective green kinetic promoters to promote hydrate formation, in order to promote the rapid formation of hydrates, leucine and tryptophan were selected to study their methane hydrate formation promotion effects. However, their effects on coalbed methane separation by hydrate method in synergy with 1,3−dioxolane are not known. Amino acids are efficient green kinetic promoters for hydrate generation and can be used in gas storage and transportation technologies. In order to study the effect of both amino acids and the thermodynamic promoter 1,3−dioxolane on hydrate separation of low concentration CBM under synergistic effect, the kinetic process of hydrate generation and the gas separation efficiency of 30% CH4+70% N2 gas mixture under different volume fraction of additives system were investigated by using leucine, tryptophan, and 1,3−dioxolane as the additives and the effect of amino acids synergism on the hydrate morphology, induction time, gas consumption rate, gas consumption, gas separation efficiency under the synergistic effect of amino acids. The experimental results showed that the CH4 volume fraction in the gas resulting from hydrate decomposition was greatly improved compared with that of the feed gas, and the CH4 volume fraction in the decomposed gas ranged from 43.92% to 57.41%, the CH4 recovery rate was from 42.11% to 62.20%, and all the systems were able to efficiently separate the CH4 gas in the mixture of 30% CH4+70% N2. Among them, when the pressure was 6 MPa, the separation and purification of CH4+N2 in the 0.3 wt% leucine + 1 mol% 1,3−dioxolane complex system was the best, with a CH4 volume fraction of 56.46% and a recovery of 64.2%. Compared with the single 1,3−dioxolane system, the complex system with the addition of leucine and tryptophan further enhanced the separation and purification of 30% CH4+70% N2, which has good application prospects and provides a theoretical basis for the development and utilization of low concentration coalbed methane.
| [1] |
XU A X,YANG L X,HUANG W,et al. Exergy,economic,exergoeconomic and environmental (4E) analyses and multi-objective optimization of a PEMFC system for coalbed methane recovery[J]. Energy Conversion and Management,2023,297:117734. doi: 10.1016/j.enconman.2023.117734
|
| [2] |
张道勇,朱杰,赵先良,等. 全国煤层气资源动态评价与可利用性分析[J]. 煤炭学报,2018,43(6):1598−1604.
ZHANG Daoyong,ZHU Jie,ZHAO Xianliang,et al. Dynamic assessment of coalbed methane resources and availability in China[J]. Journal of China Coal Society,2018,43(6):1598−1604.
|
| [3] |
廖宏,谢佩芙. IPCC AR6报告解读:短寿命气候强迫因子的气候及环境效应[J]. 气候变化研究进展,2021,17(6):685−690.
LIAO Hong,XIE Peifu. The roles of short-lived climate forcers in a changing climate[J]. Climate Change Research,2021,17(6):685−690.
|
| [4] |
韩淑萃,杨金杯. 变压精馏和萃取精馏分离四氢呋喃-水模拟及节能[J]. 化学工程,2018,46(11):6−10,62. doi: 10.3969/j.issn.1005-9954.2018.11.002
HAN Shucui,YANG Jinbei. Simulation and energy conservation for separation of tetrahydrofuran and water by pressure swing distillation and extractive distillation[J]. Chemical Engineering (China),2018,46(11):6−10,62. doi: 10.3969/j.issn.1005-9954.2018.11.002
|
| [5] |
卢晓冉. 氨基酸+1,3-二氧五环复配体系对煤层气水合分离规律影响[D]. 焦作:河南理工大学,2022:3−6.
LU Xiaoran. Effect of amino acid +1,3- dioxolane compound system on hydration and separation of coalbed methane[D]. Jiaozuo:Henan Polytechnic University,2022:3−6.
|
| [6] |
PODENKO L S,DRACHUK A O,MOLOKITINA N S,et al. Multiple methane hydrate formation in powder poly(vinyl alcohol) cryogel for natural gas storage and transportation[J]. Journal of Natural Gas Science and Engineering,2021,88:103811. doi: 10.1016/j.jngse.2021.103811
|
| [7] |
LIM S G,OH C Y,LEE J W,et al. Sustainable freshwater recovery from radioactive wastewater by gas hydrate formation[J]. Chemical Engineering Journal,2023,461:141830. doi: 10.1016/j.cej.2023.141830
|
| [8] |
ATIF M,HAIDER H Z,BONGIOVANNI R,et al. Physisorption and chemisorption trends in surface modification of carbon black[J]. Surfaces and Interfaces,2022,31:102080. doi: 10.1016/j.surfin.2022.102080
|
| [9] |
张进华,曲思建,王鹏,等. 变压吸附法提纯煤层气中甲烷研究进展[J]. 洁净煤技术,2019,25(6):78−87.
ZHANG Jinhua,QU Sijian,WANG Peng,et al. Research progress on the recovery of methane from coalbed methane by pressure swing adsorption[J]. Clean Coal Technology,2019,25(6):78−87.
|
| [10] |
YANG J F,BAI H H,SHANG H,et al. Experimental and simulation study on efficient CH4/N2 separation by pressure swing adsorption on silicalite-1 pellets[J]. Chemical Engineering Journal,2020,388:124222. doi: 10.1016/j.cej.2020.124222
|
| [11] |
LIU Y,CHEN B Y,CHEN Y L,et al. Methane storage in a hydrated form as promoted by leucines for possible application to natural gas transportation and storage[J]. Energy Technology,2015,3(8):815−819. doi: 10.1002/ente.201500048
|
| [12] |
李东,郝静远. 无机膜气体分离的温度-压力-渗透率方程及其在吸附问题上的应用[J]. 膜科学与技术,2018,38(4):127−131.
LI Dong,HAO Jingyuan. Temperature-pressure-permeability equation of gas separation in inorganic membrane and its application on adsorption[J]. Membrane Science and Technology,2018,38(4):127−131.
|
| [13] |
YUE G,LIU A X,SUN Q,et al. The combination of 1-octyl-3-methylimidazolium tetrafluorborate with TBAB or THF on CO2 hydrate formation and CH4 separation from biogas[J]. Chinese Journal of Chemical Engineering,2018,26(12):2495−2502. doi: 10.1016/j.cjche.2018.03.014
|
| [14] |
ZHONG D L,WANG W C,ZOU Z L,et al. Investigation on methane recovery from low-concentration coal mine gas by tetra-n-butyl ammonium chloride semiclathrate hydrate formation[J]. Applied Energy,2018,227:686−693. doi: 10.1016/j.apenergy.2017.08.069
|
| [15] |
ZANG X Y,LI H,ZHANG Y B,et al. Experimental investigation on the synergistic influence of tetra-n-butyl ammonium bromide(TBAB) and cyclopentane(CP) in hydrate-based gas separation[J]. Separation and Purification Technology,2023,320:124064. doi: 10.1016/j.seppur.2023.124064
|
| [16] |
LV X F,NI X Y,GUO J,et al. Kinetic characterization of gas mixture separation by hydrate method with 1,3-dioxolane and multi-walled carbon nanotubes complex synergistic system[J]. Chemical Engineering Journal,2023,475:146288. doi: 10.1016/j.cej.2023.146288
|
| [17] |
王银,赵建忠,高强,等. L-色氨酸+四氢呋喃体系下水合物法分离煤层气研究[J]. 化学工程,2022,50(5):17−21,24.
WANG Yin,ZHAO Jianzhong,GAO Qiang,et al. Separation of coalbed methane by hydrates method in L-tryptophan+tetrahydrofuran system[J]. Chemical Engineering (China),2022,50(5):17−21,24.
|
| [18] |
BAVOH C B,LAL B,OSEI H,et al. A review on the role of amino acids in gas hydrate inhibition,CO2 capture and sequestration,and natural gas storage[J]. Journal of Natural Gas Science and Engineering,2019,64:52−71. doi: 10.1016/j.jngse.2019.01.020
|
| [19] |
PRASAD P S R,SAI KIRAN B. Clathrate hydrates of greenhouse gases in the presence of natural amino acids:Storage,transportation and separation applications[J]. Scientific Reports,2018,8(1):8560. doi: 10.1038/s41598-018-26916-1
|
| [20] |
VELUSWAMY H P,LEE P Y,PREMASINGHE K,et al. Effect of biofriendly amino acids on the kinetics of methane hydrate formation and dissociation[J]. Industrial & Engineering Chemistry Research,2017,56(21):6145−6154.
|
| [21] |
YAO Y X,YIN Z Y,NIU M Y,et al. Evaluation of 1,3-dioxolane in promoting CO2 hydrate kinetics and its significance in hydrate-based CO2 sequestration[J]. Chemical Engineering Journal,2023,451:138799. doi: 10.1016/j.cej.2022.138799
|
| [22] |
ZHANG Y,BHATTACHARJEE G,ZHENG J J,et al. Hydrogen storage as clathrate hydrates in the presence of 1,3-dioxolane as a dual-function promoter[J]. Chemical Engineering Journal,2022,427:131771. doi: 10.1016/j.cej.2021.131771
|
| [23] |
DE DEUGD R M,JAGER M D,DE SWAAN ARONS J. Mixed hydrates of methane and water-soluble hydrocarbons modeling of empirical results[J]. AIChE Journal,2001,47(3):693−704. doi: 10.1002/aic.690470316
|
| [24] |
孙栋军. 水合物法提纯低浓度煤层气的实验研究[D]. 重庆:重庆大学,2015:7−9.
SUN Dongjun. Experimental study on purification of low concentration coalbed methane by hydrate method[D]. Chongqing:Chongqing University,2015:7−9.
|
| [25] |
王兰云,谢辉龙,卢晓冉,等. 水合物法分离气体的促进剂及促进机理研究进展[J]. 工程科学学报,2021,43(1):33−46.
WANG Lanyun,XIE Huilong,LU Xiaoran,et al. Research progress of promoters and promoting mechanisms for hydrate-based gas separation[J]. Chinese Journal of Engineering,2021,43(1):33−46.
|
| [26] |
FOO K S,NASHED O,LAL B,et al. The effect of nonionic surfactants on the kinetics of methane hydrate formation in multiphase system[J]. Colloids and Interfaces,2022,6(3):48. doi: 10.3390/colloids6030048
|
| [27] |
STANISLAUS J B. Single molecule study of polymer-surfactant Interactions[D]. Bayreuth:University of Bayreuth,2007.
|
| [28] |
YOSLIM J,LINGA P,ENGLEZOS P. Enhanced growth of methane–propane clathrate hydrate crystals with sodium dodecyl sulfate,sodium tetradecyl sulfate,and sodium hexadecyl sulfate surfactants[J]. Journal of Crystal Growth,2010,313(1):68−80. doi: 10.1016/j.jcrysgro.2010.10.009
|
| [29] |
BHATTACHARJEE G,GOH M N,ARUMUGANAINAR S E K,et al. Ultra-rapid uptake and the highly stable storage of methane as combustible ice[J]. Energy & Environmental Science,2020,13(12):4946−4961.
|
| [30] |
李荣,孙志高,宋佳. 静态条件下氨基酸对HCFC-141b水合物生成的促进[J]. 低温工程,2021(4):59−64. doi: 10.3969/j.issn.1000-6516.2021.04.011
LI Rong,SUN Zhigao,SONG Jia. Study on HCFC-141b hydrate formation promoted by amino acids in quiescent conditions[J]. Cryogenics,2021(4):59−64. doi: 10.3969/j.issn.1000-6516.2021.04.011
|
| [31] |
GAO Q,GUAN J,ZHAO J Z,et al. Experimental study on the medium-pressure separation characteristics of coal seam gas hydrate[J]. Gas Science and Engineering,2023,112:204951. doi: 10.1016/j.jgsce.2023.204951
|
| [32] |
GAO Q,YIN Z Y,ZHAO J Z,et al. Tuning the fluid production behaviour of hydrate-bearing sediments by multi-stage depressurization[J]. Chemical Engineering Journal,2021,406:127174. doi: 10.1016/j.cej.2020.127174
|
| 1. |
栗子剑. 基于定向钻孔技术构建煤矿井下气化通道工艺研究及应用. 煤炭技术. 2025(04): 18-21 .
| |
| 2. |
李高健，栗海滔. 松软煤层深孔定向“钻-冲-护”一体化增透促抽技术. 煤炭工程. 2025(02): 103-111 .
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: