| Citation: |
SONG Yongjun，CAO Jinghui. Damage mechanical properties of sandstone under combined action of freeze-thaw and load[J]. Coal Science and Technology，2024，52（12）：94−104. DOI: 10.12438/cst.2023-1691
|
Engineering rock mass in cold regions is subjected to the combined action of freeze-thaw and load for a long time, which causes deterioration in the mechanical properties of the rock mass. It will lead to all types of geological hazards and engineering accidents easily. In order to realistically reproduce the mechanical response characteristics of engineering rocks in cold regions during repeated freezing and thawing processes, the rocks were frozen and thawed under loaded (0, 15%σc, 30%σc, 40%σc, σc is the average peak strength of this batch of rock samples) state. And then the mechanical characterisation was carried out on this basis. The results indicate that: The quality loss rate of sandstone increases exponentially with the increase of freeze-thaw cycles, and the higher the loading level, the greater the quality loss rate, with a maximum quality loss of 0.37%. Moreover, the two end faces of sandstone is effected by the friction during the freeze-thaw with load test for a long-term. So, they are prone to rock matrix detachment after being disturbed. As the number of freeze-thaw cycles increases, the porosity of the rock sample increases in a power function, while the longitudinal wave velocity decreases in an exponential function. Rock samples at 15%σc undergoed freeze-thaw cycles, the porosity increases the slowest and the longitudinal wave velocity decreases the slowest. After 15 freeze-thaw cycles, the porosity increases by 6.00% and the longitudinal wave velocity decays by 7.91%. The peak strength and elastic modulus of rock samples are negatively correlated with the number of freeze-thaw cycles. The load level on sandstone during freeze-thaw process has a significant impact on its mechanical properties. In the early stage of freeze-thaw, sandstones under load had a stronger ability to resist freeze-thaw action. While under long-term freeze-thaw cycles, they had a weaker ability to resist freeze-thaw effects with the higher loading level of sandstones. The peak strain of sandstone is positively correlated with the number of freeze-thaw cycles. The peak strain of sandstone is effected by the load on the freeze-thaw process. The peak strain under uniaxial compression of loaded freeze-thaw rock samples is smaller than that of unloaded freeze-thaw rock samples. A segmented damage constitutive model considering the load freeze-thaw and mechanical loading factors is established through the basic principles of damage mechanics. The model has a fine degree of matching with experimental data. It can be well applied to describe the damage and failure process of loaded freeze-thaw rocks under loading.
| [1] |
宋晓波. 中国适宜露天开采的煤炭资源分布及其评价研究[J]. 煤炭工程,2015,47(12):124−126,129.
SONG Xiaobo. Distribution and evaluation of coal resources suitable for open-pit mining in China[J]. Coal Engineering,2015,47(12):124−126,129.
|
| [2] |
PARK K,KIM K,LEE K,et al. Analysis of effects of rock physical properties changes from freeze-thaw weathering in ny-ålesund region:part 1—experimental study[J]. Applied Sciences,2020,10(5):1707. doi: 10.3390/app10051707
|
| [3] |
DEPREZ M,DE KOCK T,DE SCHUTTER G,et al. A review on freeze-thaw action and weathering of rocks[J]. Earth-Science Reviews,2020,203:103143. doi: 10.1016/j.earscirev.2020.103143
|
| [4] |
李长洪,肖永刚,王宇,等. 高海拔寒区岩质边坡变形破坏机制研究现状及趋势[J]. 工程科学学报,2019,41(11):1374−1386.
LI Changhong,XIAO Yonggang,WANG Yu,et al. Review and prospects for understanding deformation and failure of rock slopes in cold regions with high altitude[J]. Chinese Journal of Engineering,2019,41(11):1374−1386.
|
| [5] |
HORI M,MORIHIRO H. Micromechanical analysis on deterioration due to freezing and thawing in porous brittle materials[J]. International Journal of Engineering Science,1998,36(4):511−522. doi: 10.1016/S0020-7225(97)00080-3
|
| [6] |
徐光苗,刘泉声. 岩石冻融破坏机理分析及冻融力学试验研究[J]. 岩石力学与工程学报,2005,24(17):3076−3082. doi: 10.3321/j.issn:1000-6915.2005.17.012
XU Guangmiao,LIU Quansheng. Analysis of mechanism of rock failure due to freeze-thaw cycling and mechanical testing study on frozen-thawed rocks[J]. Chinese Journal of Rock Mechanics and Engineering,2005,24(17):3076−3082. doi: 10.3321/j.issn:1000-6915.2005.17.012
|
| [7] |
卫梦希,李庆文,郭红臣,等. 冻融影响下不同岩性岩石物理力学特性试验研究[J]. 中国安全生产科学技术,2023,19(1):41−46.
WEI Mengxi,LI Qingwen,GUO Hongchen,et al. Experimental study on physical and mechanical properties of rocks with different lithology under influence of freeze-thaw[J]. Journal of Safety Science and Technology,2023,19(1):41−46.
|
| [8] |
高峰,熊信,周科平,等. 冻融循环作用下饱水砂岩的强度劣化模型[J]. 岩土力学,2019,40(3):926−932.
GAO Feng,XIONG Xin,ZHOU Keping,et al. Strength deterioration model of saturated sandstone under freeze-thaw cycles[J]. Rock and Soil Mechanics,2019,40(3):926−932.
|
| [9] |
王章琼,晏鄂川. 物质组构特征对片岩冻融损伤劣化的影响[J]. 岩土工程学报,2015,37(S2):86−90.
WANG Zhangqiong,YAN Echuan. Influence of material composition and structural characteristics of rock on freeze-thaw damage and deterioration of schist[J]. Chinese Journal of Geotechnical Engineering,2015,37(S2):86−90.
|
| [10] |
FU H L,ZHANG J B,HUANG Z,et al. A statistical model for predicting the triaxial compressive strength of transversely isotropic rocks subjected to freeze–thaw cycling[J]. Cold Regions Science and Technology,2018,145:237−248. doi: 10.1016/j.coldregions.2017.11.003
|
| [11] |
LU Y N,LI X P,CHAN A. Damage constitutive model of single flaw sandstone under freeze-thaw and load[J]. Cold Regions Science and Technology,2019,159:20−28. doi: 10.1016/j.coldregions.2018.11.017
|
| [12] |
杨志全,甘进,樊详珑,等. 岩石冻融损伤机理研究进展及展望[J]. 防灾减灾工程学报,2023,43(1):176−188.
YANG Zhiquan,GAN Jin,FAN Xianglong,et al. Research progress and prospect on freeze-thaw damage mechanism of rocks[J]. Journal of Disaster Prevention and Mitigation Engineering,2023,43(1):176−188.
|
| [13] |
FENG Q,JIN J C,ZHANG S,et al. Study on a damage model and uniaxial compression simulation method of frozen–thawed rock[J]. Rock Mechanics and Rock Engineering,2022,55(1):187−211. doi: 10.1007/s00603-021-02645-2
|
| [14] |
闻磊,李夕兵,唐海燕,等. 变温度区间冻融作用下岩石物理力学性质研究及工程应用[J]. 工程力学,2017,34(5):247−256.
WEN Lei,LI Xibing,TANG Haiyan,et al. Study of physico-mechanical characteristics of rock under different frozen-thawed circle temperature range and its engineering application[J]. Engineering Mechanics,2017,34(5):247−256.
|
| [15] |
刘成禹,郑道哲,张向向,等. 冻融温变速率对岩石受载特性的影响规律[J]. 岩土力学,2022,43(8):2071−2082,2175.
LIU Chengyu,ZHENG Daozhe,ZHANG Xiangxiang,et al. Influence of freeze-thaw temperature change rate on mechanics feature of rock during loading process[J]. Rock and Soil Mechanics,2022,43(8):2071−2082,2175.
|
| [16] |
HUANG S B,CAI C,YU S L,et al. Study on damage evaluation indexes and evolution models of rocks under freeze-thaw considering the effect of water saturations[J]. International Journal of Damage Mechanics,2022,31(10):1477−1505. doi: 10.1177/10567895221106241
|
| [17] |
PENG N B,HONG J,ZHU Y,et al. Experimental investigation of the influence of freeze–thaw mode on damage characteristics of sandstone[J]. Applied Sciences,2022,12(23):12395. doi: 10.3390/app122312395
|
| [18] |
CUI L Z,QIN N,WANG S,et al. Experimental study on the mechanical properties of sandstone under the action of chemical erosion and freeze-thaw cycles[J]. Advances in Civil Engineering,2021,2021(1):1−14.
|
| [19] |
朱谭谭,李昂,黄达,等. 应力-冻融耦合作用下砂岩变形与损伤特征研究[J]. 岩石力学与工程学报,2023,42(2):342−351.
ZHU Tantan,LI Ang,HUANG Da,et al. Deformation and damage characteristics of sandstone under the combined action of stress and freeze-thaw cycles[J]. Chinese Journal of Rock Mechanics and Engineering,2023,42(2):342−351.
|
| [20] |
刘波,马永君,盛海龙,等. 白垩系红砂岩冻结融化后的力学性质试验研究[J]. 岩土力学,2019,40(S1):161−171.
LIU Bo,MA Yongjun,SHENG Hailong,et al. Experiments on mechanical properties of Cretaceous red sandstone after freeze-thaw process[J]. Rock and Soil Mechanics,2019,40(S1):161−171.
|
| [21] |
FAIRHURST C E,HUDSON J A. 单轴压缩试验测定完整岩石应力−应变全曲线ISRM建议方法草案[J]. 岩石力学与工程学报,2000,19(6):802−808.
FAIRHURST C E,HUDSON J A. Draft of recommended method of ISRM for the determination of complete stress-strain curves of intact rock by uniaxial compression test[J]. Chinese Journal of Rock Mechanics and Engineering,2000,19(6):802−808.
|
| [22] |
史为政,段志,许晓亮,等. 预应力及冻融循环对砂岩物理力学特性的影响[J]. 地下空间与工程学报,2023,19(3):815−823,832.
SHI Weizheng,DUAN Zhi,XU Xiaoliang,et al. Effect of prestress and freeze-thaw cycles on physico-mechanical properties of sandstone[J]. Chinese Journal of Underground Space and Engineering,2023,19(3):815−823,832.
|
| [23] |
贾海梁,项伟,申艳军,等. 冻融循环作用下岩石疲劳损伤计算中关键问题的讨论[J]. 岩石力学与工程学报,2017,36(2):335−346.
JIA Hailiang,XIANG Wei,SHEN Yanjun,et al. Discussion of the key issues within calculation of the fatigue damage of rocks subjected to freeze-thaw cycles[J]. Chinese Journal of Rock Mechanics and Engineering,2017,36(2):335−346.
|
| [24] |
杨鸿锐,刘平,孙博,等. 冻融循环对麦积山石窟砂砾岩微观结构损伤机制研究[J]. 岩石力学与工程学报,2021,40(3):545−555.
YANG Hongrui,LIU Ping,SUN Bo,et al. Study on damage mechanisms of the microstructure of sandy conglomerate at Maijishan grottoes under freeze-thaw cycles[J]. Chinese Journal of Rock Mechanics and Engineering,2021,40(3):545−555.
|
| [25] |
梁正召,吴宪锴,唐世斌,等. 基于各向异性界面单元的岩石端部效应数值模拟[J]. 应用基础与工程科学学报,2018,26(3):526−537.
LIANG Zhengzhao,WU Xiankai,TANG Shibin,et al. Numerical silulatuon on end effect of rock specimens based on the anisotropic interface element model[J]. Journal of Basic Science and Engineering,2018,26(3):526−537.
|
| [26] |
LIU C J,DENG J R,YU S T,et al. Effect of freezing and thawing on microstructure damage and dynamic flexural tension of granite[J]. Rock Mechanics and Rock Engineering,2020,53(8):3853−3858. doi: 10.1007/s00603-020-02127-x
|
| [27] |
蔡婷婷,冯增朝,赵东,等. 基于硬化-损伤机制的贫煤蠕变本构模型研究[J]. 岩土力学,2018,39(S1):61−68.
CAI Tingting,FENG Zengchao,ZHAO Dong,et al. A creep model for lean coal based on hardening-damage mechanism[J]. Rock and Soil Mechanics,2018,39(S1):61−68.
|
| [28] |
CHENG H,ZHOU X P,PAN X K,et al. Damage analysis of sandstone during the creep stage under the different levels of uniaxial stress using NMR measurements[J]. Fatigue & Fracture of Engineering Materials & Structures,2021,44(3):719−732.
|
| [29] |
徐晓炼,张茹,戴峰,等. 煤岩特性对超声波速影响的试验研究[J]. 煤炭学报,2015,40(4):793−800.
XU Xiaolian,ZHANG Ru,DAI Feng,et al. Effect of coal and rock characteristics on ultrasonic velocity[J]. Journal of China Coal Society,2015,40(4):793−800.
|
| [30] |
张慧梅,杨更社. 冻融岩石损伤劣化及力学特性试验研究[J]. 煤炭学报,2013,38(10):1756−1762.
ZHANG Huimei,YANG Gengshe. Experimental study of damage deterioration and mechanical properties for freezing-thawing rock[J]. Journal of China Coal Society,2013,38(10):1756−1762.
|
| [31] |
罗学东,黄成林,肜增湘,等. 冻融循环作用下蒙库铁矿边坡岩体物理力学特性研究[J]. 岩土力学,2011,32(S1):155−159.
LUO Xuedong,HUANG Chenglin,RONG Zengxiang,et al. Study of physico-mechanical characteristics of rocks in slope of Mengku iron mine under freezing-thawing cyclic effect[J]. Rock and Soil Mechanics,2011,32(S1):155−159.
|
| [32] |
张慧梅,杨更社. 冻融与荷载耦合作用下岩石损伤模型的研究[J]. 岩石力学与工程学报,2010,29(3):471−476.
ZHANG Huimei,YANG Gengshe. Research on damage model of rock under coupling action of freeze-thaw and load[J]. Chinese Journal of Rock Mechanics and Engineering,2010,29(3):471−476.
|
| [33] |
张全胜,杨更社,任建喜. 岩石损伤变量及本构方程的新探讨[J]. 岩石力学与工程学报,2003,22(1):30−34. doi: 10.3321/j.issn:1000-6915.2003.01.005
ZHANG Quansheng,YANG Gengshe,REN Jianxi. New study of damage variable and constitutive equation of rock[J]. Chinese Journal of Rock Mechanics and Engineering,2003,22(1):30−34. doi: 10.3321/j.issn:1000-6915.2003.01.005
|
| [34] |
邓华锋,胡安龙,李建林,等. 水岩作用下砂岩劣化损伤统计本构模型[J]. 岩土力学,2017,38(3):631−639.
DENG Huafeng,HU Anlong,LI Jianlin,et al. Statistical damage constitutive model of sandstone under water-rock interaction[J]. Rock and Soil Mechanics,2017,38(3):631−639.
|
| [35] |
贾蓬,毛松泽,孙占阳,等. 冻融损伤砂岩的能量演化及分段本构模型[J]. 中南大学学报(自然科学版),2023,54(3):908−919. doi: 10.11817/j.issn.1672-7207.2023.03.010
JIA Peng,MAO Songze,SUN Zhanyang,et al. Energy evolution and piecewise constitutive model of freeze-thaw damaged sandstone[J]. Journal of Central South University (Science and Technology),2023,54(3):908−919. doi: 10.11817/j.issn.1672-7207.2023.03.010
|
| [1] | LEI Zhaoyuan, LI Feng, ZHAO Zikui, LI Lei, HUANG Xingli. Breaking mechanism of hard thick roof during the life cycle of large mining height working face[J]. COAL SCIENCE AND TECHNOLOGY, 2025, 53(7): 25-34. DOI: 10.12438/cst.2024-0546 |
| [2] | PANG Yihui, BI Jinglong, YUAN Pengzhe, ZHAO Baofu, DING Ziwei. Coal mining equipment lifecycle management system architecture and key technology[J]. COAL SCIENCE AND TECHNOLOGY, 2025, 53(2): 339-350. DOI: 10.12438/cst.2024-1609 |
| [3] | JIA Mengxuan, WANG Jinman, LI Yuning, ZHANG Yafu, GAO Tingyu, WU Dawei. Ecological restoration of mines based on Nature-based Solution: a review[J]. COAL SCIENCE AND TECHNOLOGY, 2024, 52(8): 209-221. DOI: 10.12438/cst.2023-1306 |
| [4] | LI Shuzhi, LI Xueliang, YIN Dawei. Several basic issues of ecological restoration of coal mines under background of carbon neutrality[J]. COAL SCIENCE AND TECHNOLOGY, 2022, 50(1): 286-292. |
| [5] | WANG Zhenyu, LIU Xiaomin, LIU Tingxi, WANG Wenjuan, XUE Lian. Study on influencing factors of coal-water coordinated mining based on theory of full life cycle[J]. COAL SCIENCE AND TECHNOLOGY, 2021, 49(12): 243-251. |
| [6] | ZHANG Xuhui, GUO Huanhuan, MA Hongwei, CHE Wanli, PAN Gege, ZHANG Chao, ZHAO Youjun, ZHANG Yuliang, MAO Qinghua, FAN Hongwei, DU Yuyang, XUE Xusheng, WANG Chuanwei, DONG Ming, LIU Peng, XIA Jing, CAO Xiangang. Research and application of green evaluation method for shearer based on life cycle[J]. COAL SCIENCE AND TECHNOLOGY, 2021, 48(6): 205-212. |
| [7] | WEN Caihuan WANG Wendong, . Study on ecological restoration of open pit mines based on UAV oblique photogrammetry technology[J]. COAL SCIENCE AND TECHNOLOGY, 2020, 48(10). |
| [8] | MAO Zhengjun, WANG Shuangming, AN Ning. Research on slope ecological restoration and management in mining areas on loess plateau：planting support technology of PVC plates lattice anchor beam[J]. COAL SCIENCE AND TECHNOLOGY, 2020, 48(4). |
| [9] | QIN Zhu. Research and application of life cycle service system of mining equipment[J]. COAL SCIENCE AND TECHNOLOGY, 2019, (4). |
| [10] | YU Jiacheng, WANG Gang, LIU Weidong, NING Yongjie, JIANG Hanhan. Life-cycle information integration and working condition discriminational gorithm of mine equipment[J]. COAL SCIENCE AND TECHNOLOGY, 2019, (4). |
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: