QIN Yujin，SU Weiwei，LU Shouqing，et al. Research on energy instability of composite coal based on unsteady diffusion to cause disaster[J]. Coal Science and Technology，2024，52（7）：126−138
. DOI: 10.12438/cst.2023-0984| Citation: |
QIN Yujin，SU Weiwei，LU Shouqing，et al. Research on energy instability of composite coal based on unsteady diffusion to cause disaster[J]. Coal Science and Technology，2024，52（7）：126−138 . DOI: 10.12438/cst.2023-0984
|
In China, due to the influence of geological tectonics, the phenomenon of primary structural coal and tectonic coal stratification exists in many coal seams. The existence of tectonic coal leads to a sharp increase in the risk of composite coal seam outburst, which seriously restricts the safe production of coal mines. According to the gas diffusion state in soft and hard composite coal bodies, the mechanical instability law of composite coal with unsteady diffusion was simulated and analyzed. The calculation model of adsorbed gas expansion energy by unsteady diffusion was established, and the influence of steady and unsteady diffusion on the expansion energy of adsorbed gas was discussed. The control effect of adsorbed gas expansion energy on outburst was analyzed from the perspective of energy, and the disaster-causing mechanism of composite coal outburst instability by unsteady diffusion was elucidated. The results shown that, the existence of tectonic coals in the composite coal seams could increase the plastic damage degree to the adjacent primary structural coals, and improve the gas migration rate within the plastic zone of the primary structural coals, thus increasing the risk of coal and gas outbursts. The expansion energy of adsorbed gas in primary structural coal and tectonic coal under unsteady diffusion condition was 0.50 - 0.57 times and 3.36 - 3.38 times higher than that under steady diffusion conditions, respectively. The presence of tectonic coals in composite coal seams led to a huge gas concentration difference between the fissure and matrix systems within the primary structural coal, which resulted in the rapid desorption of adsorbed gas within the primary structural coal matrix, increasing the expansion energy of adsorbed gas in the adjacent primary coals, and thus significantly increased the outburst risk of composite coal seam.
| [1] |
唐巨鹏,邱于曼,马圆. 煤中CH4扩散影响因素的分子动力学分析[J]. 煤炭科学技术,2021,49(2):85−92.
TANG Jupeng,QIU Yuman,MA Yuan. Molecular dynamics analysis of influencing factors of CH4 diffusion in coal[J]. Coal Science and Technology,2021,49(2):85−92.
|
| [2] |
刘世奇,高德,桑树勋,等. 不同粒度构造煤的视电阻率特征[J]. 煤炭科学技术,2022,50(12):162−169.
LIU Shiqi,GAO Deyi,SANG Shuxun,et al. Characteristics of apparent resistivity of coals with different particlesizes[J]. Coal Science and Technology,2022,50(12):162−169.
|
| [3] |
秦跃平,徐浩,毋凡,等. 密度梯度驱动的煤粒瓦斯解吸扩散模型及试验研究[J]. 煤炭科学技术,2022,50(1):169−176. doi: 10.3969/j.issn.0253-2336.2022.1.mtkxjs202201016
QIN Yueping,XU Hao,WU Fan,et al. Gas desorption and diffusion model driven by density gradient in coal particle and its experimental study[J]. Coal Science and Technology,2022,50(1):169−176. doi: 10.3969/j.issn.0253-2336.2022.1.mtkxjs202201016
|
| [4] |
赵健光,王猛,马如英,等. 基于压汞法对黔西青龙矿构造煤孔院结构特征的研究[J]. 煤炭科学技术,2022,50(10):159−168.
ZHAO Jianguang,WANG Meng,MA Ruying,et al. Study on pore structure characteristics of tectonic coal in Oin-glong Coal Mine in Western Guizhou based on mercury injection[J]. Coal Science and Technology,2022,50(10):159−168.
|
| [5] |
邓绪彪,胡青峰,魏思民. 构造煤的成因−属性分类[J]. 工程地质学报,2014,22(5):1008−1014.
DENG Xubiao,HU Qingfeng,WEI Simin. Genesis and property classification of tectonic coal[J]. Journal of Engineering Geology,2014,22(5):1008−1014.
|
| [6] |
蒋静宇,史孝宁,程远平,等. 急速卸压条件下构造煤体应力释放规律试验研究[J]. 采矿与安全工程学报,2024,41(3):634−644.
JIANG Jingyu,SHI Xiaoning,CHENG Yuanping,et al. Study on stress release law of tectonic coal under the condition of rapid unloading confining pressure[J]. Journal of Mining and Safety Engineering,2024,41(3):634−644.
|
| [7] |
李云波,谭志宏. 构造煤层位对煤与瓦斯突出的影响数值分析[J]. 煤矿安全,2011,42(4):5−8.
LI Yunbo,TAN Zhihong. Numerical analysis for the relationship of tectonic-coal layer's horizon in coal and gas outburst[J]. Safety in Coal Mines,2011,42(4):5−8.
|
| [8] |
舒龙勇,王凯,张浪,等. 突出煤体受载变形破坏声发射行为演化特征[J]. 采矿与安全工程学报,2018,35(3):589−597.
SHU Longyong,WANG Kai,ZHANG Lang,et al. Investigation on acoustic emission behaviour evolution characteristics of outburst coal under uniaxial compression[J]. Journal of Mining and Safety Engineering,2018,35(3):589−597.
|
| [9] |
卢守青,张永亮,撒占友,等. 软硬组合煤体塑性破坏与突出能量失稳判据[J]. 采矿与安全工程学报,2019,36(3):583−592.
LU Shouqing,ZHANG Yongliang,SA Zhanyou,et al. Criterion of plastic failure and outburst energy instability of soft and hard composite coal[J]. Journal of Mining and Safety Engineering,2019,36(3):583−592.
|
| [10] |
LU S,LI L,CHENG Y,et al. Mechanical failure mechanisms and forms of normal and deformed coal combination containing gas:Model development and analysis[J]. Engineering Failure Analysis,2017,80:241−252. doi: 10.1016/j.engfailanal.2017.06.022
|
| [11] |
B B HODOT. Coal and gas outburst [M]. Beijing:China Industry Press,1966.
|
| [12] |
朱连山. 通过能量计算探讨煤和瓦斯突出机理[J]. 煤矿安全技术,1982(3):1−8.
ZHU Lianshan. Discussion on mechanism of coal and gas outburst by energy calculation[J]. Mining Safety & Environmental Protection,1982(3):1−8.
|
| [13] |
张庆贺,李宁,段昌瑞. 煤岩破坏过程弹性能与瓦斯膨胀能演化特性试验研究[J]. 煤矿安全,2019,50(6):32−35,40.
ZHANG Qinghe,LI Ning,DUAN Changrui. Experimental study on evolution characteristics of elastic energy and gas expansion energy during failure process of coal[J]. Safety in Coal Mines,2019,50(6):32−35,40.
|
| [14] |
郑哲敏. 从数量级和量纲分析看煤与瓦斯突出的机理[M]. 北京:科学出版社,2004:416−426.
|
| [15] |
胡千庭,文光才. 煤与瓦斯突出的力学作用机理[M]. 北京:科学出版社,2013.
|
| [16] |
WANG S. Gas transport,sorption,and mechanical response of fractured coal[J]. Dissertations & Theses - Gradworks,2012.
|
| [17] |
姜永东,郑权,刘浩,等. 煤与瓦斯突出过程的能量分析[J]. 重庆大学学报,2013,36(7):98−101,20.
JIANG Yongdong,ZHENG Quan,LIU Hao,et al. An analysis on the energy of coal and gas outburst process[J]. Journal of Chongqing University,2013,36(7):98−101,20.
|
| [18] |
LIU T,LIN B. Time-dependent dynamic diffusion processes in coal:Model development and analysis[J]. International Journal of Heat and Mass Transfer,2019,134:1−9. doi: 10.1016/j.ijheatmasstransfer.2019.01.005
|
| [19] |
卢守青,李铭杰,司书芳,等. 基于能量理论的含瓦斯煤体突出失稳倾向分析[J]. 煤矿安全,2022,53(10):105−111.
LU Shouqing,LI Mingjie,SI Shufang,et al. Analysis of outburst instability tendency of coal containing methane based on energy theory[J]. Safety in Coal Mines,2022,53(10):105−111.
|
| [20] |
WANG Z Y,CHENG Y P,WANG L,et al. Characterization of pore structure and the gas diffusion properties of tectonic and intact coal:Implications for lost gas calculation[J]. Transactions of the Institution of Chemical Engineers Process Safety and Environmental Protection,Part B,2020,135(1):12−21.
|
| [21] |
MORA C A,WATTENBARGER R A. Analysis and verification of dual porosity and CBM shape factors[J]. Journal of Canadian Petroleum Technology,2009,48(2):17−21. doi: 10.2118/09-02-17
|
| [22] |
AN F H,CHENG Y P,WU D M,et al. The effect of small micropores on methane adsorption of coals from Northern China[J]. Adsorption,2013,19(2):83−90.
|
| [23] |
PABST W,GREGOROVá E,TICHá G. Elasticity of porous ceramics:a critical study of modulusporosity relations[J]. Journal of the European Ceramic Society,2006,26(7):1085−1097. doi: 10.1016/j.jeurceramsoc.2005.01.041
|
| [24] |
卢守青. 基于等效基质尺度的煤体力学失稳及渗透性演化机制与应用[D]. 徐州:中国矿业大学,2016.
LU Shouqing. Mechanical failure and permeability evolution mechanism of coal based on equivalent matrix scale and its application[D]. Xuzhou:China University of Mining and Technology,2016.
|
| [25] |
DRUCKER D C,PRAGER W. Soil mechanics and plastic analysis or limit design[J]. Qapplmath,2013,10(2):157−165.
|
| [26] |
LU S,ZHANG Y,SA Z,et al. Evaluation of the effect of adsorbed gas and free gas on mechanical properties of coal[J]. Environmental Earth Sciences,2019,78(6):1−15.
|
| [27] |
LU S,ZHANG Y,SA Z,et al. Damage‐induced permeability model of coal and its application to gas predrainage in combination of soft coal and hard coal[J]. Energy Science & Engineering,2019,7(5):1352−1367.
|
| [28] |
LU S Q,LI M J,SA Z,et al. Discrimination of gas diffusion state in intact coal and tectonic coal:model and experiment[J]. Fuel,2022,325:124916. doi: 10.1016/j.fuel.2022.124916
|
| [29] |
安丰华. 煤与瓦斯突出失稳蕴育过程及数值模拟研究[D]. 徐州:中国矿业大学,2014.
AN Fenghua. Preparation and initiation of coal and gas outburst and its numerical modelling study[D]. Xuzhou:China University of Mining and Technology,2014.
|
| 1. |
解盘石, 张颖异, 伍永平, 杜玉乾, 杨航, 黄宝发, 林伟典, 易磊磊, 徐辉, 冯春. 基于倾角效应的“支架-围岩”数字孪生模拟试验平台研制与测试. 煤炭学报. 2025(06)
| |
| 2. |
王巍，王文，张广杰. 神东矿区浅埋大采高工作面支架-围岩耦合关系及支架适用性研究. 河南理工大学学报(自然科学版). 2025(02): 32-41 .
| |
| 3. |
樊武振. 大倾角采煤工作面综采设备防倒防滑技术研究. 陕西煤炭. 2025(03): 159-163 .
| |
| 4. |
段航宇. 推移装置液压支架系统参数优化分析. 凿岩机械气动工具. 2025(03): 31-33 .
| |
| 5. |
王磊，孙凯，袁瑞甫，齐俊艳. 基于EtherCAT的液压支架智能控制系统研究. 河南理工大学学报(自然科学版). 2025(03): 53-63 .
| |
| 6. |
姚绪亮，郑泽辉，史翔. 支架液压系统的优化设计与分析. 设备管理与维修. 2025(06): 100-102 .
| |
| 7. |
伍永平，许英瑞，解盘石，王红伟，郎丁，皇甫靖宇，强旭博，杜玉乾，王乐辰，茹笑辉，王正富. 急倾斜中厚煤层双斜开采顶板垮落堆积与应力演化特征. 工矿自动化. 2024(12): 18-26+75 .
|
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: